Florida Construction Cost Estimating
Ohio
Call: (866)-493-4944
Write to us: enquiry@quantity-takeoff.com

Top 10 Myths in Concrete Construction

In the concrete construction myths and misinterpretations are prevalent. Meanwhile, we commences with some of these myths. We are going to uncover the ten popular myths, those are completely faulty and wrong.

 

Myth one: Specify the concrete mix by the numbers of bags of cement.
The fact is, mixes should be specified based on performance requirements, not just cement content.
Specifying bags of cement without tying in the amount of water use no specification at all. One of the most important properties have a concrete mix is the water to cement ratio mixes need to meet performance requirements. Including a minimum compressible strength, that is governed by the amount of water in the mix, not just the cement content.

 

Myth Two: Adding water to the mix is the only way to increase the slump.
The fact is, there are many ways to to increase the slump of concrete besides adding more water.
Add in just gallon of water 21 cubic yards of concrete can increase lump one-inch decrease compressible strength 150 to 200 PSI.

 

Myth Three: Curing concrete means letting it dry.
The fact is,Concrete needs water to continue to hydrate and gain strength.
As cement hydrates new chemical compounds from in the fresh concrete. The new compounds are responsible for sharing. Hardening and strength properties have concrete loss of water prevents continued hydration. Curing maintains a satisfactory moisture content and temperature with in the concrete to ensure the desired properties develop the longer the period of time, that you cured concrete.

 

Myth Four: No bleed water and a successful footprint test means a thumbs up for concrete finishing.
The fact is, these general finishing guidelines don't always prevent slab surface defects. Finishing concrete is an art you experience to know whim to begin finishing operations the germs. Over finishing and premature finishing hard concrete finishers.

 

Myth Five: Calcium chloride is an antifreeze agent.
The fact is,Calcium chloride is an accelerator only and not an antifreeze. The concrete came still freeze if it is not properly protected. Very slow in low temperature if you serve accelerators such as calcium chloride, it increases strength development at an early stage. To avoid problems while placing concrete in cold weather.

 

Myth Six: Placing concrete on frozen ground without any precautions.
But the fact is, precautions must be taken to protect concrete and prevent future soil in adverse weather conditions. Cement put on a solidified sub-evaluation may settle unevenly when the sub-grade defrosts, prompting splitting. The distinction in temperature between the solidified soil and the warm solid can likewise bring about fast cooling of the solid and retard the rate of solidifying. In a perfect world, the dirt temperature ought to be as close as would be prudent to the solid temperature when set. There are routines accessible to defrost the ground and permit the arrangement of solid, including curing covers and hydroponic warming frameworks.

 

Myth Seven: Reinforced concrete won't crack.
The fact is,Structural reinforcement does not prevent concrete from cracking due to volume changes.
Volume changes caused by temperature and moisture cycles. Structural reinforcement does not prevent cracking but instead holds the crack faces together. Cement put on a solidified sub-evaluation may settle unevenly when the sub-grade defrosts, prompting splitting. The distinction in temperature between the solidified soil and the warm solid can likewise bring about fast cooling of the solid and retard the rate of solidifying. In a perfect world, the dirt temperature ought to be as close as would be prudent to the solid temperature when set. There are routines accessible to defrost the ground and permit the arrangement of solid, including curing covers and hydroponic warming frameworks.

Myth Eight: Fresh concrete that is flat and level will remain constant after hardening.
The fact is, concrete can change shape while setting. In addition to horizontal movements caused by changes in moisture and changes in shape including curling.

 

Myth Nine: Concrete is impermeable.
The fact is, even the most dense concrete is somewhat porous. Concrete is permeable moisture and other substance in the former liquid and vapor can pass through it. Depending on how porous the concrete is to make concrete less permeable. And more watertight use mix designs with the lower water to cement.

 

Myth Ten: The higher the concrete strength, the more durable the concrete.
The fact is, compressible strength alone does not determine the concrete's durability.
Cement put on a solidified sub-evaluation may settle unevenly when the sub-grade defrosts, prompting splitting. The distinction in temperature between the solidified soil and the warm solid can likewise bring about fast cooling of the solid and retard the rate of solidifying. In a perfect world, the dirt temperature ought to be as close as would be prudent to the solid temperature when set. There are routines accessible to defrost the ground and permit the arrangement of solid, including curing covers and hydroponic warming frameworks.

Top 10 Myths in Concrete Construction

Site Design & Develop by

Global Associates

Join Our Email List